環氧樹脂防腐環氧地坪面涂裝工藝的關鍵在于涂裝基面的處理，它關系到涂裝層能否牢固附于地面，涂裝層是否平整光亮，我公司非常注重對基面的處理。潔凈區的地面應整體性好、平整、耐磨、耐撞擊，不易積聚靜電，易除塵清洗。目前使用環氧自流平地面較普遍，環氧自流平地坪是一種新型的較為理想的地面潔凈材料。它具有耐腐蝕和潔凈的雙重作用，優良的耐磨性能及平整光潔性，從而保證了廠房車間地面的潔凈度和整體的美觀。

Epoxy resin anti-corrosion floor coating process is the key to the treatment of the base surface, it is related to the coating layer can be firmly attached to the ground, whether the coating is smooth and bright, my company attaches great importance to the treatment of the base surface. Clean area of the ground should be good integrity, smooth, wear-resistant, impact-resistant, not easy to accumulate static electricity, easy to dust cleaning. Epoxy self-leveling floor is widely used at present. Epoxy self-leveling floor is a new kind of ideal ground cleaning material. It has the dual role of corrosion resistance and cleanliness, excellent wear resistance and smoothness, thus ensuring the cleanliness of the workshop floor and the overall beauty.

1、為使涂裝達到完美效果，專家建議：對于尚未找平的地面由施工公司參與工地的水泥找平層的找平處理。土建方找平時，在水泥初凝時由施工公司專業地面機械對地面進行磨平處理。在此基礎上所做的環氧涂裝層的表面效果會更平整、光亮，使用壽命也會提高。

1. In order to achieve the perfect effect of painting, experts suggest that the construction company should take part in leveling the cement leveling layer on the ground which has not been leveled. When the cement is initially set, the ground is ground by the professional ground machinery of the construction company. On this basis, the surface effect of the epoxy coating will be smoother and brighter, and the service life will be improved.

2、待水泥層干燥后大約28 天，用打磨機對地面進行整體打磨處理，使其表面平整，水泥毛細孔全部張開。

2. About 28 days after the cement layer is dried, the ground is polished with a grinder to make the surface smooth and the cement capillaries open.

3、對于水泥地面有油污(食用油、機油)，先用美地堅麗處理劑噴灑于用水沖濕的地表面，反復擦洗直到無油污為止。

3. For oily cement floors (cooking oil, oil), spray the surface wetted with water with Medicinal Rubber and scrub repeatedly until there is no oil pollution.

4、對于環氧地坪堿性太大(ph>8)的，先用有關處理劑中和，然后用清水沖洗。

4, for the floor too alkaline (ph>8), first use the relevant treatment agent neutralization, and then rinse with water.

5、對于潮濕的地面通過吸水、擦干、太陽燈照、熱風機吹烘，使其干燥達到施工要求。

5. The wet ground is dried to meet the construction requirements by absorbing water, drying, sunlight and hot air blower.

6、對于有舊油漆的地面如金剛砂地面、舊油漆地面，先用機械鏟除舊油漆，然后對不良水泥、金剛砂地面進行處理同時對地面打毛。地面經過這樣處理后，不牢固的舊水泥及金剛砂表面被清除掉，并且形成粗毛面，從而提高新涂層的附著力，提高涂裝環氧地坪的使用壽命。

6. For old painted ground such as diamond ground, old painted ground, first with mechanical shovel old paint, and then on the poor cement, diamond ground treatment and grooming. After the ground is treated in this way, the unstable surface of old cement and diamond is removed, and coarse surface is formed, so as to improve the adhesion of the new coating and improve the service life of the coated floor.

蘇州環氧樹脂防腐地坪

Suzhou epoxy resin anticorrosive floor 環氧地坪的驗收標準：

Acceptance criteria for epoxy floor:

1、環境溫度為25℃時，施工后2-3天應達到實干，即硬度達到完成固化的80%左右；

1. When the ambient temperature is 25 C, the hardness should reach 80% after 2-3 days.

2、表面不能出現發粘現象；

2, the surface can not appear sticky phenomenon;

3、氣泡：平涂型、砂漿型無氣泡，自流平允許1個小氣泡/10平方米；

3, bubble: flat coated, mortar type no bubbles, self leveling allows 1 small bubbles /10 square meters;

4、流平性好，無鏝刀痕，大面積接口處基本平整；

4, good leveling, no trowel marks, large area of the interface is basically smooth.

5、無浮色發花，顏色均勻一致，大面積接口處允許有極不明顯的色差；

5, no floating color and flower, uniform color, large area interface allows very insignificant chromatic aberration;

6、無粗雜質，但允許有空氣中的浮塵掉落在造成的極小缺陷；

6, there is no coarse impurity, but it allows the floating dust in the air to drop into the minimal defect.

7、地坪表面應平整平滑，光澤度應達到設計要求（高光澤≥90、有光≥70、半光50～70），平涂型為有光、水性為半光～無光；

7. The surface of the floor should be smooth and smooth, and the gloss should meet the design requirements (high gloss (> 90, gloss (> 70, half gloss 50-70). The flat coating type is glossy and the water-borne is half gloss-no gloss.

8、桔皮、砂漿防滑面效果應很明顯。無揮發性有機物排放，被廣泛用于現代工業地坪的涂飾中。

8, orange peel and mortar anti slip surface effect should be very obvious. No VOC emissions are widely used in modern industrial floor finishing.