隨著無錫企業對環氧地坪產品了解，越來越多的場合開始使用無錫環氧地坪，要做出優質的環氧地坪漆工程，除了要選擇正規無錫環氧地坪施工廠家的地坪漆材料，嚴格按照地坪漆施工工藝進行施工之外，在地坪漆施工前、施工中、施工后還要注意以下細節：

With people's understanding of epoxy floor paint products, more and more occasions began to use epoxy floor paint, to make high-quality floor paint project, in addition to the choice of normal floor paint manufacturer's floor paint materials, in strict accordance with the construction process of floor paint construction, before, during and after the construction of floor paint, the following details should be paid attention to: 

一、施工前的準備工作：

Preparations before construction:

1、檢查基礎地面情況：是否平整，將過高或過低位置做好標識，對其進行打磨或修補。

1. Check the ground condition of the foundation: Whether it is flat or not, mark the position too high or too low, and grind or repair it.

2、要清楚知道地面的養護時間，施工環境的情況，溫度、濕度、是否有防水層等。因為環氧地坪漆的施工是受環境的影響的，溫度不能過高或過低，濕度也要在合適的范圍內。夏天的養護時間是7天，溫度低或比較潮濕的地方則10天。

2. Know clearly the maintenance time of the ground, the construction environment, temperature, humidity, whether there is a waterproof layer, etc. Because the construction of epoxy floor paint is affected by the environment, the temperature should not be too high or too low, and the humidity should also be within the appropriate range. Maintenance time is 7 days in summer and 10 days in low or humid areas.

3、檢查混凝土地面的強度。這是為了防止施工后環氧地坪漆出現起砂、空鼓等不良現象。強度較低的混凝土地面，在施工前要特別注意吸塵，清理干凈后，涂刷上環氧封閉底漆，將混凝土地面的毛細孔封閉起來，阻止水汽，雜物等滲入地面，增強混凝土地面的強度。

3. Check the strength of concrete floor. This is in order to prevent the occurrence of sand, empty drum and other undesirable phenomena in epoxy floor paint after construction. The concrete floor with lower strength should be cleaned up before construction. After cleaning, epoxy sealing primer should be applied to seal the capillary holes of the concrete floor to prevent water vapor and sundries from penetrating into the ground and enhance the strength of the concrete floor.

4、檢查施工場所環境是否潔凈。如果環氧地坪漆混入灰塵等雜物的話，會使環氧地坪出現顆粒狀或不平整的情況。

4. Check whether the environment of the construction site is clean. If the epoxy floor paint is mixed with dust and other impurities, it will make the epoxy floor appear granular or uneven.

二、施工過程中需要注意的地方：

2. The points needing attention in the construction process:

1、材料配比的量要精準，地坪漆材料要攪拌均勻。

1. Material proportioning should be precise and flooring paint materials should be stirred evenly.

2、施工時涂布的涂層厚度在均勻，固化實干后才可以進入下道工序。

2. The coating thickness is uniform during construction and can enter the next process only after solidification and drying.

3、每施工一道涂層后檢查下施工后的涂布表面是否有質量問題，及時處理。

3. Check the quality of the coated surface after each coat construction, and deal with it in time.

4、注意保持施工環境的衛生，避免臟物掉入未固化的涂層中。

4. Attention should be paid to the hygiene of the construction environment to avoid the dirt falling into the uncured coating.

三、施工后需要注意的地方：

3. Points needing attention after construction:

1、地坪漆涂層全部施工完畢后，清理現場把所的施工工具和材料全部帶離現場。

1. After finishing the construction of the floor paint coating, clean up the site and take all the construction tools and materials away from the site.

2、24小時固化后待表面涂膜完成固化可上人行走，三天后檢收，一周后可投入使用。

2. After curing for 24 hours, it can walk on the surface until the film is cured. After three days, it can be checked and put into use after one week.

3、投入使用后的環氧地坪工程要注意維護保養，禁止破壞，定期檢查環氧涂層的表面情況，有損壞的及時報修。

3. After putting into use, the epoxy floor project should pay attention to maintenance, prohibit damage, regularly check the surface condition of the epoxy coating, and timely report the damage.